Skip to Content

How to Change Fuel Pump on 99 Ford F150?

To replace your fuel pump, you should first disconnect the fill line. To do this, cycle the keys to the “run” position and wait for 10 seconds before cranking the engine. Then, remove the fuel tank from underneath. The next step is to locate the fuel pump module. If you can’t find it, you can use a flathead screwdriver to pry it out of the tank.

Remove the old fuel pump and gasket, if applicable. Make sure that the old gasket is not attached to the fuel pump. If not, remove it and replace it with the new one. Use a silicon lubricant to ensure a good seal, and then reinstall the mounting bolts. Connect the fuel lines to the new pump assembly and reconnect the negative battery cable. Reinstall the mounting bolts.

To access the fuel pump, remove the fuel tank from the truck. You’ll find it behind the cab. The fuel tank is held in place by a round fuel pump module held in place by six bolts. Before you remove the pump, disconnect the fuel lines. Disconnect the evaporative hoses. Safety clips may be attached to these lines. You can use a 3/8″ Ford fuel line disconnect tool to remove them.

How Do You Remove a Fuel Pump From a Ford F150?

If your vehicle has trouble starting or is not performing at its optimum level, you may need to replace the fuel pump. The following instructions will walk you through the procedure step-by-step. To remove the fuel pump, you must first drain the tank. To drain the tank, you need a car jack and stands and the time to get underneath the truck. Make sure you disconnect the ground battery cable as well. Then, use a socket or ratchet to remove the fuel tank shield.

First, remove the gas pump assembly from the fuel tank. The fuel pump assembly is located on top of the fuel tank and protrudes from the fuel tank. You can remove the fuel pump assembly by unscrewing the eight-mm bolts holding it in place. If it sticks to the rubber seal, use a flathead screwdriver to pry it out. Once it’s free, remove the bolts holding the fuel tank in place.

READ ALSO:  How Much Does a 1996 Ford F150 Weigh?

Where is the Fuel Filter on a 1999 Ford F150?

Your truck is equipped with a fuel filter that keeps your engine clean and running efficiently. The fuel filter connects the fuel tank to the engine, where it is injected into the cylinders. The fuel pump forces the fuel through the filter at high pressure. If the fuel filter gets clogged with sediment, it can’t do its job properly. If this happens, you’ll have to replace the fuel filter.

You can find your fuel filter beneath your truck, near the fuel tank. It’s mounted in a fuel line on the frame rail, under pressure. My 99 F150 5.4 replaced its motor in Sept. 2011, and it has about one hundred and eighty thousand miles since then. I’m glad to report that my truck runs perfectly now. I highly recommend replacing the fuel filter if you notice a difference in performance.

Your F150 has many advanced safety features and a number of optional components. Like an oil filter, the fuel filter removes small particles from gasoline. When it becomes dirty, it’s time to replace it. If you notice a decrease in gas mileage, your fuel filter may be clogged. A clogged fuel filter can lead to misfires in the cylinders, which can damage your spark plugs and fuel pump.

Where is the Fuel Pump Relay on a 99 Ford F150?

If you’ve ever wondered where the Fuel Pump Relay is located in a 99 Ford F150, you aren’t alone. The engine compartment of the vehicle is filled with fuses and relays. The driver’s side fender contains a fuse panel with a layout and numbers on the lid. While the diagrams are helpful, they don’t indicate what each fuse controls.

If the fuel pump doesn’t work, you can test the relay by thumping on the tank. The sound may awaken the fuel pump motor. The contact may be renewed for a few seconds before the pump shuts down completely. If that doesn’t work, try swapping out the fuel pump relay. You can replace the fuel pump relay yourself if the fuel pump itself isn’t at fault.

When the fuel pump fails, there’s no power reaching the fuel pump. When this happens, the engine won’t start and the fuel pump relay cuts power to it. Fortunately, the fuel pump relay is fairly cheap, only costing $9 to $39, but the cost of replacing the pump can run anywhere from $457 to $732. The parts and labor costs are $228 to $443, depending on the location of the fuel pump relay.

READ ALSO:  How Big is a 16 Foot Truck?

How Do I Know When My Fuel Pump is Bad?

First, you can check the fuse box. The fuse box is generally located under the front hood. If you see any burned fuses, you need to replace them. If it’s not blown, use a multimeter to see if there’s power to the fuel pump. The fuel pump’s power is provided by a wire harness located near the fuel tank. To check if there’s power, disconnect the wire harness and connect the multimeter’s lead to the earth.

In case the pump is not blowing fuel, look for other problems in the system first. A bad fuel pump relay could be causing weak fuel rail pressure. A clogged fuel filter could also be causing low pressure. Depending on the model, you may also notice low fuel pressure, which can indicate a faulty oxygen sensor. Check all these components and replace the fuel pump if necessary.

How Do You Test a Fuel Pump?

If you’ve ever wondered how to test a fuel pump on a 99 Ford F150, you’ve come to the right place. The fuel pump is located in the fuse box under the hood, near the battery. When you notice a rumbling noise, stop immediately. The sound is likely caused by a malfunctioning fuel pump. A faulty fuel pump will not produce enough fuel pressure for your vehicle to run, and can even trigger a P0087 trouble code. Low fuel pressure can cause many other problems, too, including an oxygen sensor related code.

To test a fuel pump, you’ll first need a special adaptor. Then, connect a wire to the positive wire of the fuel pump. You’ll need to plug this into a voltage meter. Next, place the amp clamp over the positive wire of the fuel pump. Turn the ignition key to the “on” position. Then, whack the tank with a rubber mallet. Depending on the type of motor in the fuel pump, this method may work to start the car temporarily.

READ ALSO:  What Truck is Best For Towing?

How Do You Fix a Fuel Pump Without Replacing It?

The symptoms of a failing fuel pump are similar to other problems with your Ford F150. The engine will run poorly, especially when trying to go up a hill with a full load. The fuel pump can be difficult to detect by sight, so pay close attention to its noise. You can also check for fuses, broken wires, and clogged fuel socks. If you notice any of these symptoms, you should take your vehicle to a Ford service center.

Check the fuse box, usually located under the hood. If you suspect the fuse is burned out, you should replace the fuse. If the fuse is not blown, test the wire harness to see if it is receiving an adequate power supply. If the wire harness is disconnected, check the power source to the fuel pump. Be sure to earth the multimeter lead to the ground. Check the wire harness to confirm the power supply.

How Long Does It Take to Replace a Fuel Pump?

Usually, a dead fuel pump is due to several reasons. The pump will have trouble delivering the proper amount of gas into the engine, which results in an erratic engine performance. Old fuel pumps may even be the result of debris that has gotten stuck in them. The fuel filter is only effective at blocking large particles, not microscopic particles. In some cases, a faulty fuel pump may result in a loud noise and lower engine performance.

Most people can replace a fuel pump on their own for around $200. However, some late model cars can’t be replaced separately, as they are integrated into the fuel sending unit. In those cars, replacing the fuel pump is more difficult. The cost of the pump and labor will vary. For a 99 Ford F150, the replacement can cost anywhere from $150 to $500, depending on the make and model of the car.

Learn More Here:

1.) Latest on Ford F150

2.) Ford F Series – Wikipedia

3.) Official Ford Support

4.) F150 History